USED OIL GENERATORS AND BURNERS

Hazardous Waste Program fact sheet
07/2014
Division of Environmental Quality Director: Leanne Tippett Mosby
PUB134

Used Oil
Used oil is defined as petroleum-derived and synthetic oils which have been spilled into the environment or used for (1) lubrication/cutting oil; (2) heat transfer; (3) hydraulic power; or (4) insulation in dielectric transformers. The definition of used oil excludes used petroleum-derived or synthetic oils which have been used as solvents. (Note: Used ethylene glycol is not regulated as used oil under 10 CSR 25.)

The improper disposal of used oil causes needless damage to ground and surface water and wastes a valuable renewable resource, making us more dependent on imported oil. The Missouri Department of Natural Resources has adopted and amended federal regulations for used oil that provide strong safeguards against potential types of mishandling that may occur. The management standards cover all segments of the used oil recycling system. While generators are the largest segment of this industry, the most stringent standards apply to used oil processors and re-refiners because they handle the largest quantities of used oil. The standards are designed to encourage recycling while protecting human health and the environment.

This fact sheet describes the management standards for used oil processors and re-refiners under 10 CSR 25-11.279, which became effective on Aug. 28, 1994.

Generators
A generator is any business that produces used oil through commercial or industrial operations, or that collects it from these operations or from private households and exempted farmers. Householders who change their own oil (do-it-yourselfers) are not covered by the used oil regulation.

Farmers who generate an average of 25 gallons or less of used oil per month from farm vehicles or machinery in a calendar year are also exempt. Generators are no longer required to register with the department prior to shipping used oil.

Off-Specification Used Oil Burners
A used oil burner is a facility where used oil not meeting the specification requirements is burned for energy recovery in an industrial furnace, boiler or hazardous waste incinerator.

Management Standards
Used oil generators must comply with the following standards:

Burners of off-specification used oil must:

Mixtures
Generators should not mix used oil with hazardous waste. Mixtures of used oil and hazardous waste are hazardous waste. The only allowed mixing is mixtures of used oil with characteristic ignitable hazardous waste and listed hazardous waste which is listed solely because it is ignitable. The resultant mixture must not exhibit the characteristic of ignitability.

Conditionally exempt small quantity generators (CESQG) of hazardous waste are allowed to mix their ignitable hazardous waste with used oil and manage the mixture as used oil.

Self –Transportation
Generators are allowed to self-transport up to 55 gallons of used oil to approved collection centers or to aggregation points owned by the same generator, so long as they use their own vehicle or an employee’s vehicle to self-transport the used oil.

Space Heaters
Generators may burn their own used oil, as well as used oil received from household do-it-yourselfers and exempt farmers, in used oil-fired space heaters which have a design capacity of not more than 0.5 million Btu per hour and are vented to the ambient air. The department is no longer requiring resource recovery certification for this activity.

On-site Treatment
The following activities are not considered processing so long as the used oil is generated onsite and is not sent to an off-site used oil burner:

Additional Information
More information is available on related technical bulletins and inspection checklists

For more information call or write:
Missouri Department of Natural Resources
Hazardous Waste Program
P.O. Box 176
Jefferson City, MO 65102-0176
1-800-361-4827 or 573-751-3176
573-751-7869 fax
www.dnr.mo.gov/env/hwp